10 ㎡ Low Noise and Energy Industrial Freeze Dryer Machine for Sale
10 ㎡ Low Noise and Energy industrial freeze dryer machine for sale Quick Detail: This freeze dryer is widely used in food, fruit, vegetable, fish, sea cucumer...
10 ㎡ Low Noise and Energy industrial freeze dryer machine for sale
Pre-freeze drying in situ, to reduce the tedious operation of the drying process;
Silicone oil as a circulating medium, high precision temperature control, shelf temperature ≤ 1 ℃, uniform drying effect;
· Shelf temperature adjustable, controllable, fumble, pilot and production processes;
· As the drying chamber and cold trap for the split structure, water capture ability, short drying time;
Touch screen operation, PLC control, display drying curve;
Square tray is not deformed, easy to operate, easy to clean;
Inflatable valve configuration, can be filled with dry inert gas;
Optional with eutectic point test device.
· Optional host computer software to achieve remote control.
· Optional ozone disinfection function
· Refrigeration system protection and regulation device: the use of internationally renowned brands of products, accurate, stable, safe and reliable.
High-pressure protection system: When the system exhaust pressure exceeds the allowable pressure, automatically cut off the freezer operation, to prevent accidents.
Medium-pressure pressure regulation system: In a two-stage refrigeration system, the appropriate intermediate pressure on the cooling system performance and life are crucial. When the intermediate pressure is lower than the set value, the system will automatically start to adjust. To create a condition for the unmanned operation of lyophilizer.
* Hydraulic pressure protection system: When the freezer is in a long run state, the freezer at any time to monitor the hydraulic pressure to prevent the refrigerator due to lack of oil damage.
· Motor temperature protection system: When the freezer motor temperature is higher than the set value, in order to protect the freezer, the system will automatically stop the freezer operation.
· Low Temperature Oil Return Regulating System: It is important how to return the refrigeration oil smoothly to the crankcase when the freezer is operating at very low evaporating temperature for a long time (the freezer is often "burned" in a system lacking refrigeration oil) . When there is a lack of freezer oil in the crankcase, the automatic start-up of the system will establish a suitable oil level in the crankcase. To create a condition for the unmanned operation of lyophilizer.
· Exhaust temperature control system: When the freezer exhaust temperature is too high, the system automatically starts the cooling system to prevent high-pressure part of the over-temperature operation. To create a condition for the unmanned operation of lyophilizer.
Moisture-proof stroke adjustment system: When the freezer is in high-load operation, the system can automatically enter the adjustment process, moisture-proof stroke or even "liquid hammer" phenomenon. To create a condition for the unmanned operation of lyophilizer.
· Automatic liquid receiving device: When the freezer is in standby mode, the device automatically runs back the system to retain the refrigerant in the tank, in order to facilitate the boot again.
Machine start protection: When all the safety conditions of the equipment are available, the whole machine can start running.
Machine structure: vertical, front and rear split rack (easy to transport, in place).
Effective area of shelves
Maximum Condenser capacity
Could be changed to follow customer’s country voltage
10T/Hr (T＜28℃, P=0.1-0.15MPa)
subject to the actual design
Dry Chamber Material
SUS304/ 6mm thick
Dry Chamber Shape and dimension
Drying chamber+Condencer Φ1300×3280
Hand knob lock
Door Open direction
Right to left
Decided by customer
Installed on the front
Medical o section silicone rubber seal
The top layer of the shelves is temperature compensation
Stainless steel tray
395*395*30/ 2mm thick
Distance between shelves
Shelf lowest temperature
Shelf highest temperature
Shelf Cooling Rate
Heating power consumption
prevent the tray cross over the shelf
SUS304/ 6mm thick
Shape and dimension
Coil pipe material
Circular coil pipe
Coil pipe water catching area
Condenser lowest temperature
Installed on the side
spray + immersion
BITZER 25HP two-stage motor
Shelf temperature uniformity
Oil pressure differential controller
Dehumidification drying filter
High/low voltage protection relay
Corrugated Damping Pipe
Manual stop valve
Refrigerating solenoid valve
Red Copper Pipe
φ38 Stainless steel seamless pipe
LEYBOLD D40B 2.2KW
Roots vacuum pump
LEYBOLD WAU251 1.1KW
Vacuum Pipe Shock Resistance
Pump air flow
vacuum solenoid valve
Automatic open or close with vacuum pump
From the atmospheric pressure dropped to 133 Pa≤20min
304 seamless pipe
Denmark Grundfos 1.1KW
Comply with the standard of Q/IAKX002-97
ALFA LAVAL (Sweden)
Electric Heating pipe 4KW*2pcs 8Kw
Circulating fluid tank dimension
System Monitoring Software
Vertical control cabinet
SIEMENS CPU 226 CN AC/DC/relay
Thermocouple extension module
SIEMENS EM 231 CN 4(4 TC)
Analog input module
SIEMENS EM 231 CN(4 AI)
Taiwan Panel Master PT070
Cable of HMI and PLC
Switching Power Supply
Taiwan MW companies / 24V/5V
1) We have applied the CE, ISO9001 certificate for our products and get the good technical test report, who is the international famous third party test institute.
2) Our products are designed and produced completely according to European standard, which are oriented as high efficiency and high quality.
3) We have applied the CE, ISO9001 certificate for our products and get the good technical test report, who is the international famous third party test institute.
If the 10 ㎡ low noise and energy industrial freeze dryer machine for sale caters to your requirement, welcome to buy the precise equipment made in China from our factory. We are one of the professional manufacturers and suppliers in China who can offer you unmatched services and prices. And the customized service is also available. Don't hesitate any more.